Why Is My ATV So Difficult To Start - Yamaha Raptor Forum
 
LinkBack Thread Tools Display Modes
post #1 of 1 (permalink) Old 01-20-2017, 02:21 PM Thread Starter
Editorial Content
 
Join Date: Dec 2014
Posts: 32
Why Is My ATV So Difficult To Start







Quote:
ATV AnswerMan looks into a problem Honda Rancher 400

When my Honda Rancher 400 sits for a day or more, gas drains back to the tank making it a five-minute crank to start. What can I do to fix this?

Joe Howard

Hi Joe,

Well there is one thing that is for certain, the gas is not draining back into the tank. The tank on your TRX400FM sits well above the carburetor (right between your legs under the handlebars) and cannot return once it leaves via the petcock. There are several things that can be causing the slow start, though, so letís look at a few options to try and figure out your issue. Since you did not list the year I have to guess itís at least a 1995 to 2007 variant of the Rancher, as these were the years a 400cc engine was built for the Rancher models.

One of the reasons a carbureted engine is a little tough to start sometimes is the compression of the engine is too low to draw ample fuel into the cylinder to burn. If the rings, piston or cylinder are not working properly, not enough suction or compression is produced to pull the fuel in. Do a compression test to determine if the engine is within spec according to Hondaís service manual.

Another problem you might encounter are the valves not being set in the correct tolerances or being worn past service limits, causing what are essentially timing issues. Shimming or adjusting the valves needs to be performed by a service tech or experienced mechanic, as you can cause more damage by not getting this service done correctly the first time.

These are all real issues that a trusty old ATV will encounter sooner or later and if you do not service the engine properly in the timely intervals required by the manufacturer,then you will see it sooner rather than later. Look at these items carefully and I think you will find that you need to give this TRX400F a few hugs and kisses to get back into the trail.
Read more about Why Is My ATV So Difficult To Start at ATV.com.
ATV.com is offline  
Reply

Quick Reply
Message:
Options

Register Now



In order to be able to post messages on the Yamaha Raptor Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.

Password:


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:
OR

Log-in










Thread Tools
Show Printable Version Show Printable Version
Email this Page Email this Page
Display Modes
Linear Mode Linear Mode



Similar Threads
Thread Thread Starter Forum Replies Last Post
why can i pull start my friends quad to start but wont start any other way rightaway Raptor 700 Discussion 14 06-12-2012 03:24 PM
Why is my Raptor sputtering, popping, & backfiring? Why do my headers glow red? Osiel General 660 Discussion 9 11-14-2007 09:14 AM
why why why rap7hundred Off-Topic Lounge 11 08-30-2007 01:19 PM
How difficult is it to raise the gas tank for service. Tiggyboot Raptor 700 Maintenance 12 04-21-2007 10:06 PM
How difficult is it to align the front end of a raptor? Blue06Raptor Raptor 350 Discussion 4 04-14-2007 08:03 PM

Posting Rules  
You may not post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On

 
For the best viewing experience please update your browser to Google Chrome