2004 raptor 660 no spark even jumping the solenoid - Yamaha Raptor Forum
 3Likes
  • 1 Post By DEZPERADO
  • 2 Post By DEZPERADO
 
LinkBack Thread Tools Display Modes
post #1 of 9 (permalink) Old 04-18-2019, 03:26 PM Thread Starter
Junior Member
 
Join Date: Apr 2019
Posts: 1
2004 raptor 660 no spark even jumping the solenoid

My 04 raptor 660 started by jump start and ran for a little while then I went to jump it again and no spark across the solenoid I have replaced the stator ignition coil and solenoid(solenoid was a few moths ago tho) what could be wrong
Garretgawe is offline  
Sponsored Links
Advertisement
 
post #2 of 9 (permalink) Old 04-19-2019, 01:37 PM
Member
 
Join Date: Apr 2019
Location: Tyrie,North East Aberdeenshire.Scotland
Posts: 68
Does engine turn over on starter without spark plug in?
Scotscockney is offline  
post #3 of 9 (permalink) Old 04-19-2019, 03:54 PM
I may be getting older, but I refuse to grow up!

 
Join Date: Jun 2012
Location: PACIFIC N.W.
Posts: 9,904
Garage
So, you have been shorting the solenoid to start it? What's wrong with the start switch. You replaced the solenoid, was it a factory part? No spark now would mean the battery cables, connections or solenoid are bad. Don't forget to check the ground wire. You'll need a VOM or a test light.

WELCOME TO THE FORUM.
Scotscockney likes this.

2007 RAPTOR 700, SAND QUAD, 11:1 CP, +5 HR CRANK, PC3, +2 TB, LONE STAR XC +1, +1 A-ARMS, HD TIE RODS, JOGACA REAR SHOCK, ASV LEVERS, +4 REAR AXLE, DR.D REVERSE, ODI GRIPS, 1 1/8 CARBON BARS, DG BUMPER. BILLET: GAS CAP, BRAKE COVER, THROTTLE LEVER, BAR MOUNTS. LED LIGHTS'
DEZPERADO is offline  
 
post #4 of 9 (permalink) Old 04-25-2019, 12:40 PM
Junior Member
 
Join Date: Apr 2019
Posts: 7
I'm having the same issue as well. Seems like I have voltage everywhere I'm supposed to, solenoid is good, connections are clean, battery is fully charged... Like there's no life in it.
3rd Monkey is offline  
post #5 of 9 (permalink) Old 04-25-2019, 02:36 PM
Member
 
Join Date: Apr 2019
Location: Tyrie,North East Aberdeenshire.Scotland
Posts: 68
Quote:
Originally Posted by 3rd Monkey View Post
I'm having the same issue as well. Seems like I have voltage everywhere I'm supposed to, solenoid is good, connections are clean, battery is fully charged... Like there's no life in it.
do you get a clicking from solenoid when trying to crank engine?
Scotscockney is offline  
post #6 of 9 (permalink) Old 04-25-2019, 02:50 PM
Junior Member
 
Join Date: Apr 2019
Posts: 7
Quote:
Originally Posted by Scotscockney View Post
Quote:
Originally Posted by 3rd Monkey View Post
I'm having the same issue as well. Seems like I have voltage everywhere I'm supposed to, solenoid is good, connections are clean, battery is fully charged... Like there's no life in it.
do you get a clicking from solenoid when trying to crank engine?
No clicking, nothing if I put a wrench across the solenoid posts either.
3rd Monkey is offline  
post #7 of 9 (permalink) Old 04-25-2019, 03:05 PM
Member
 
Join Date: Apr 2019
Location: Tyrie,North East Aberdeenshire.Scotland
Posts: 68
QM is THE electrics man,follow his advice n hopefully you'll sus it out.Good luck n don't forget to check valve clearance as it turns out to be REALLY important
Scotscockney is offline  
post #8 of 9 (permalink) Old 04-25-2019, 04:14 PM
I may be getting older, but I refuse to grow up!

 
Join Date: Jun 2012
Location: PACIFIC N.W.
Posts: 9,904
Garage
Quote:
Originally Posted by 3rd Monkey View Post
No clicking, nothing if I put a wrench across the solenoid posts either.
You should start your own thread.

But since I'm here, you have a battery, connection or cable issue. A common problem is corrosion in the battery cables. Yes, you'll read 12volts, but it won't pass any current. Take some jumper cables from battery ground to the starter body ground. Then the other cable from battery positive and the other end to jump the solenoid.

If you get a spark and cranking, your cables or connection are bad.

If you don't get a spark, your battery or connections are bad. Try jumping from the wife's car.

WELCOME TO THE FORUM.
Dale_W and Scotscockney like this.

2007 RAPTOR 700, SAND QUAD, 11:1 CP, +5 HR CRANK, PC3, +2 TB, LONE STAR XC +1, +1 A-ARMS, HD TIE RODS, JOGACA REAR SHOCK, ASV LEVERS, +4 REAR AXLE, DR.D REVERSE, ODI GRIPS, 1 1/8 CARBON BARS, DG BUMPER. BILLET: GAS CAP, BRAKE COVER, THROTTLE LEVER, BAR MOUNTS. LED LIGHTS'
DEZPERADO is offline  
post #9 of 9 (permalink) Old 04-25-2019, 04:26 PM
I may be getting older, but I refuse to grow up!

 
Join Date: Jun 2012
Location: PACIFIC N.W.
Posts: 9,904
Garage
Quote:
Originally Posted by 3rd Monkey View Post
No clicking, nothing if I put a wrench across the solenoid posts either.
Quote:
Originally Posted by DEZPERADO View Post
You should start your own thread.

But since I'm here, you have a battery, connection or cable issue. A common problem is corrosion in the battery cables. Yes, you'll read 12volts, but it won't pass any current. Take some jumper cables from battery ground to the starter body ground. Then the other cable from battery positive and the other end to jump the solenoid.

If you get a spark and cranking, your cables or connection are bad.

If you don't get a spark, your battery or connections are bad. Try jumping from the wife's car.

WELCOME TO THE FORUM.
Sorry, I see you do have your own thread. Test as above, but chances are you'll need a new wire harness form the correct year(s).

2007 RAPTOR 700, SAND QUAD, 11:1 CP, +5 HR CRANK, PC3, +2 TB, LONE STAR XC +1, +1 A-ARMS, HD TIE RODS, JOGACA REAR SHOCK, ASV LEVERS, +4 REAR AXLE, DR.D REVERSE, ODI GRIPS, 1 1/8 CARBON BARS, DG BUMPER. BILLET: GAS CAP, BRAKE COVER, THROTTLE LEVER, BAR MOUNTS. LED LIGHTS'
DEZPERADO is offline  
Reply

Quick Reply
Message:
Options

Register Now



In order to be able to post messages on the Yamaha Raptor Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.

Password:


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:
OR

Log-in










Thread Tools
Show Printable Version Show Printable Version
Email this Page Email this Page
Display Modes
Linear Mode Linear Mode



Similar Threads
Thread Thread Starter Forum Replies Last Post
No rear brake, even with new parts SweetWaterSurprise Raptor 700 Discussion 5 11-13-2018 01:47 PM
2004 660 intermittent no spark problem HillJack Raptor 660 Maintenance 1 11-13-2016 02:39 AM
In DIRE NEED OF HELP, No Spark 2004 Raptor 350 JosephMcGov Raptor 350 Discussion 9 02-01-2014 07:29 PM
Big Problem, no start, no power, no fuel cycle, no neutral light 700gitrdone Raptor 700 Modifications 6 02-05-2009 06:30 PM
2004 RAPTOR 660 NO SPARK. PLEASE HELP BRUTEL 1 Raptor 660 Maintenance 10 11-17-2007 03:59 AM

Posting Rules  
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On

 
For the best viewing experience please update your browser to Google Chrome