Yamaha Raptor Forum - View Profile: QuadManiac

QuadManiac QuadManiac is offline

Master of the Electron

  Visitor Messages

Showing Visitor Messages 41 to 42 of 42
  1. BossMan660r
    06-19-2010 05:09 PM - permalink
    Okay, so measuring from the lug on the starter motor and the case with the start button on I got 1.4V Now from the negative lug on the battery to the lug on the solenoid I got several readings and they were bouncing between 10V and 14V....it was all over the place. So it looks like from your recommendations its either starter cable or ground cable. Where should we go from here?
  2. Fulgore1018
    06-16-2010 07:49 PM - permalink
    sorry to bother you but you seem to be very knowledgeable about raptor 660. i have a question for you if you don't mind answering it.. i have a 2002 raptor 660 and after it warms up to about 190 degrees f it decides to shut down and will not start until it cools down a bit. but it does not do it all of the time.. i have seen that there are posts about a plug wire and solenoid but how would you check that.. and it ticks very loud from the valve area i adjusted the valve lash to spec on the intake and exhaust valves and no improvement i am wondering if i would have to repair the top end.. in any rate i would appreciate it if you could help me out on these issues.. thank you for your time..

  About Me

  • About QuadManiac
    Electrical Engineer
    San Diego, CA
    Disable Sidebar in Forum view
  • Signature
    '01 660 Raptor, Burgard +2+1 arms, YFZ Shocks, LSR anti-vibe, CTR pipe, jetted, K&N
    '01 Polaris Scrambler 400, K&N
    '02 Honda 400ex, Big Gun pipe, jetted, K&N, Lonestar +2 A-arms, Lonestar anti-vibe
    '04 Suzuki LTZ400
    '16 RZR XP4 1000 Turbo


Total Posts
Visitor Messages
General Information
  • Last Activity: 08-20-2019 03:18 PM
  • Join Date: 04-30-2007
  • Referrals: 1


Showing Friends 1 to 4 of 4


11:35 AM - ChadStr mentioned QuadManiac in post Jetting
QuadManiac thanks for the help,...
06:37 AM - Matt.Garey mentioned QuadManiac in post 03 raptor 660 HELP
QuadManiac The air box appears...


12:07 AM - Cody7210 quoted QuadManiac in post 2001 Raptor 660 No spark PLEASE HELP!
Could well be. The orange wi...
12:07 AM - QuadManiac quoted Its_Chaynes in post 2001 Raptor 660 No spark PLEASE HELP!
i plugged it up to the janky wir...
11:46 PM - Its_Chaynes quoted QuadManiac in post 2001 Raptor 660 No spark PLEASE HELP!
Cody is dead WRONG. 01 is a ba...
11:28 PM - Its_Chaynes quoted QuadManiac in post 2001 Raptor 660 No spark PLEASE HELP!
There is no 'kill switch' on a ...
01:32 AM - QuadManiac quoted Dale_W in post '04 Spark Plug Cap Resistance
When we were testing the co...
01:43 PM - 03LimitedEditionRaptor quoted QuadManiac in post Need Jetting Advice
Approximately: 160L/165R Mik...
07:59 PM - Cody7210 quoted QuadManiac in post Binding in transmission
What gear is it IN as far as yo...
12:43 AM - QuadManiac quoted Chrisdmax in post Need help please...
Also forgot to mention when I ...
04:51 PM - Chrisdmax quoted QuadManiac in post Need help please...
The reverse light will start fl...
03:26 PM - Chrisdmax quoted QuadManiac in post Need help please...
What's your idle speed? Raise ...
12:22 AM - QuadManiac quoted Cody7210 in post Deleted Posts
09:48 PM - QuadManiac quoted Raptorman87 in post Shutting off and idles fast
It will just die with no warning...
08:48 PM - Edwinm quoted QuadManiac in post quad wont start in gear
As said, connect together the b...
03:08 PM - 03LimitedEditionRaptor quoted QuadManiac in post My 660 won't start
You didn't disassemble, clean a...
01:53 AM - QuadManiac quoted jsingmore in post My 660 won't start
I cleaned the carbs just by ta...
05:38 PM - bigdawg2016 quoted QuadManiac in post Good idea to remove snorkel?
Removing the snorkel can increa...
04:38 PM - QuadManiac quoted Bryan Holsinger in post 04 raptor 660
Actually the choke plunger was corro...
06:45 AM - Sixnickells quoted QuadManiac in post 03 Raptor 660 no spark
Did you unplug the rectifier an...
03:25 PM - QuadManiac quoted 03rappy660r in post idle screw o ring part numbers
Opinions on the longer pilot scr...
03:46 PM - QuadManiac quoted Elite13 in post No spark
No reverse light and 12v to ...
For the best viewing experience please update your browser to Google Chrome